An official website of the United States government
Here's how you know
A .mil website belongs to an official U.S. Department of Defense organization in the United States.
A lock (lock ) or https:// means you’ve safely connected to the .mil website. Share sensitive information only on official, secure websites.

News | Dec. 11, 2017

Alaska Guard fuel supply specialist keeps aircraft flying

By Sgt. David Bedard 134th Public Affairs Detachment, Alaska Army National Guard

For Alaska Army National Guard Sgt. Cody Foster, attending Basic Combat Training at Fort Jackson, South Carolina, was his first time to the South, or anywhere outside of Alaska for that matter.

To fight the unfamiliar, stifling heat and humidity, the Kenai native did what the drill sergeants told him to do: he drank lots of water.

Because he succeeded at Fort Jackson and later during Advanced Individual Training at Fort Lee, Virginia, the petroleum supply specialist with E Company, 1st Battalion, 207th Aviation Regiment, learned the value of following instructions in the Army.

When it comes to safely pumping fuel into 1-207th Aviation UH-60 Black Hawk helicopters, following instructions to the letter is critical to the job, Foster said.

Foster dispenses the fuel from an eight-wheel-drive Heavy Expanded Mobility Tactical Truck tanker parked close to the flight line at Bryant Army Airfield on Joint Base Elmendorf-Richardson.

During the unit's December 2017 drill, Foster partnered with fellow petroleum supply specialist Spc. Jesse Gray to top off a UH-60 following a sortie. The duo scrambled to the cab of their HEMTT fueler and drove a few hundred yards to the helicopter.

The Soldier's uniforms are different than their ground unit counterparts. They wear a special fire-retardant jacket for obvious reasons; they don fuel-proof gloves to ensure any fuel spilled on them in subzero weather doesn't instantly cover their hands with frostbite. Eye and hearing protection are always a must.

For a "cold" refuel, the Black Hawk is tied down and has ground wires staked into grounding points. Foster and Gray also grounded the HEMTT to ensure a spark wouldn't ignite the volatile JP-8 fuel onboard.

"Any and all static that comes from the hose, the line and the aircraft all goes straight to ground and stops us from having a [mishap,]" Foster said.

Foster and Gray worked with the deliberate speed and precise attention to detail of a NASCAR pit crew.

Foster paid out the refueling hose from a spool on the back of the HEMTT before hooking up to the idle UH-60. Gray controlled a valve at the truck end, giving him the ability to cut fuel flow if he identified an emerging hazard.

The operation was quick, limited in speed primarily by the time it takes to fill the fuel tanks of the helicopter. Rapid as it is, refueling is merely the culmination of Foster's efforts.

Before he can fill up a whirlybird and send it back into action, Foster has to get the fuel. He said he requisitions the JP-8 from the Air Force fuel farm on the base. The fuel is then stored in large tanks operated locally by the battalion.

Before the fuel is certified for use, Foster tests it for contaminants and water content.

"Every time we receive fuel, we need to do a sample on each tank to make sure the fuel we have is good," he said. "It's never come up bad, but it's just an extra precaution."

As layered and nuanced as refueling helicopters on an active airfield is, Foster is ready to do the same mission in austere conditions in a combat zone.

Foster's company is equipped and trained to establish an ad-hoc logistics operation, called a forward arming and refueling point, on an improvised airfield.

Without Bryant Air Field's hardstand helicopter parking spots with their pre-positioned tie-down and grounding points, Foster said he relies on the equipment in his tanker to ground the helicopter in the field.

Besides eating field rations, skipping a few showers, and living out of a duffel bag, the job otherwise changes little in a field environment, Foster said. Even during a "hot" refuel when the helicopter is running and often flies away after topping off, the fundamentals of grounding the bird and maintaining safety stay the same, Foster said.

Sgt. Zachary Adams, a petroleum supply squad leader in E Company, said Foster serves as a good role model for other Soldiers in the unit. Adams said Foster takes pride in his work and is known for his reliability and accountability to the standards of the job.

"He really takes the time to ensure he and other Soldiers take the time to do the job safely," Adams said.

Because the unit's charter never stops, Foster said he relishes staying busy in support of the fight.

"My favorite part of this job is we always have a mission," he said. "Those birds need to fly. Pilots always need flight time.

"There's always something to do here," Foster continued. "It requires the same amount of brainwork as it does physical activity. It's never boring."

Editor's note: The original story can be viewed on the National Guard website.